Note:

* PRL0801 series are designated as PRL0801x-y where x can be E (Enclosed Type with rear side built-in fan) or F (U-Chassis Type with top

side built-in fan) or U (U-Chassis), y can be 05, 09, 12, 15, 18, 24, 30, 36, 40, 48, 54.

* U Type: U-Chassis @300W max. with min. 25CFM forced airflow; 150W under convection cooling (Option: vented top cover).

* E Type: Enclosed with rear side built-in fan @300W max.

* F Type: U-Chassis with top built-in fan @300W max.

* All output range are covered in agencies certification and the preset voltage will be set as standard models if any request is not preset

output then should contact us in advance.

* Ripple and noise is measured from 10KHZ to 20MHz bandwidth at output with parallel 0.1µF ceramic and 22µF electrolytic capacitors.

* Providing peak power to 600W within 500uS for all models, longer duty duration need contact manufacture.

* 1% minimum load is required to maintain the ripple and regulation.

* Output is fully isolated.

Input Connector (CN1):

U and F Type: Mating Molex Part No. VHR-5N or equivalent (5pin, 3 used), or Terminal Block: Howder M3 screws 3 pin 6.35mm center Part No.

HD-601-3P; PCB Labeling: L=Line; N=Neutral; G=Chassis Ground .

E Type: IEC320 snap-in mounting type or Terminal Block: Howder HD-602-3P.

Output Connector (CN2):

Mating Molex Part No. VHR-6N

Terminal block-Dinkle P830N, M5 screws.

Output Pin Assignment:

(See table in right).

Mounting Inserts:

6Paces M3. Maximum Penetration 3.8mm sees outline drawing for location.

Logic signal connector (CN3):

Mating JST XHP-4 or equivalent (CHYAO SHIUNN JS-2001-04);

Mating Pins: JST SXH-002T-P0.6 FOR AWG 30 to 26.

Fan driver connector (FAN1):

Mating connector is JST P/N XHP-3 (3 pins 0.98 pitch) or equivalent (CHYAO SHIUNN JS-2001-03).

Dinkle

Molex

V+: Pin 2

V+: Pin 4 ~ 6

V-: Pin 1

V-: Pin 1 ~ 3

OUTLINE DRAWING:

Copy Right Ultra Level Tech Co., Ltd 2015, All Right Reserved. Specifications subject to change without notice.

Model

Output

Range

Preset

Voltage

Max. Output Power or Current

Regulation

Ripple

& Noise

Type U & E & F (forced

air)

Type U (Convection)

PRL0801x-05

2 ~ 5V

5V

42A

20A

+/- 1%

1%

PRL0801x-09

7 ~ 11V

9 V

27.27A

13.64A

+/- 1%

1%

PRL0801x-12

12 ~ 13.8V

12 V

300W

150W

+/- 1%

1%

PRL0801x-15

14 ~ 16V

15 V

300W

150W

+/- 1%

1%

PRL0801x-18

17 ~ 22V

18V

300W

150W

+/- 1%

1%

PRL0801x-24

23 ~ 28V

24V

300W

150W

+/- 1%

1%

PRL0801x-30

29~ 34V

30V

300W

150W

+/- 1%

1%

PRL0801x-36

35 ~ 43V

36V

300W

150W

+/- 1%

1%

PRL0801x-48

44 ~ 52V

48V

300W

150W

+/- 1%

1%

PRL0801x-54

53 ~ 60V

54V

300W

150W

+/- 1%

1%

ULTRA LEVEL TECH CO., LTD.

www.ultralevel.com.tw

Tel:+886-2-29180118

Fax:+886-2-29181465